Inactivation of Listeria monocytogenes and Salmonella spp. During Cooking of Country Ham and Fate of L. monocytogenes and Staphylococcus aureus During Storage of Country Ham Slices.

Thermal inactivation studies were undertaken on Listeria monocytogenes and Salmonella spp. inoculated on the surface of country ham. Hams (average = ca. 3.4 ± 0.5 kg each; average = ca. ≥18% shrinkage) were used as provided by the processor (i.e., "salted hams"), desalted in tap water (i.e., "desalted hams"), or dried for an additional period (i.e., "extra-dried hams"). Hams were surface inoculated (ca. 9.5 log CFU/ham) with a multistrain cocktail of L. monocytogenes or Salmonella spp. and cooked within a bag ina circulating water bath to an internal temperature of 130°F (54.4°C) instantaneous, 145°F (62.8°C) and held for 4 min, 153°F (67.2°C) and held for 34 s, or 160°F (71.1°C) instantaneous. Regardless of ham type, all four time and temperature combinations tested herein delivered a ≥6.7-log reduction of cells of L. monocytogenes or Salmonella spp. Differences in product pH, moisture content, or aw did not have an appreciable impact on the thermal inactivation of L. monocytogenes or Salmonella spp. on country ham. In addition, shelf-life studies were undertaken using slices of "salted" country ham that were surface inoculated (ca. 5.5 log CFU/slice) with a multistrain cocktail of L. monocytogenes or Staphylococcus aureus and then stored at 20°C. Levels of S. aureus increased by ca. ≤1.4 log CFU/slice during storage for 90 days, whereas levels of L. monocytogenes remained relatively unchanged (≤0.2 log CFU/slice increase). Our data validated that cooking parameters elaborated in the U.S. Department of Agriculture's Food Safety and Inspection Service Cooking Guideline for Meat and Poultry Products (Revised Appendix A) are sufficient to deliver significant reductions (ca. ≥6.8 log CFU/ham) in levels of L.monocytogenes and Salmonella spp. on country ham. In addition, in the event of postprocessing contamination, country ham may support the outgrowth of S. aureus or survival of L. monocytogenes during storage at 20°C for 90 days.

Occurrence of Listeria monocytogenes in Ready-to-Eat Meat and Poultry Product Verification Testing Samples from U.S. Department of Agriculture-Regulated Producing Establishments, 2005 through 2017.

ABSTRACT: Ready-to-eat (RTE) meat and poultry product samples collected between 2005 and 2017 from RTE-producing establishments for the U.S. Department of Agriculture, Food Safety and Inspection Service (FSIS) ALLRTE/RTEPROD_RAND (random) and RTE001/RTEPROD_RISK (risk-based) sampling projects were tested for Listeria monocytogenes (Lm). Data for 45,897 ALLRTE/RTEPROD_RAND samples collected from 3,607 distinct establishments and 112,347 RTE001/RTEPROD_RISK samples collected from 3,283 distinct establishments were analyzed for the presence of Lm. These data were also analyzed based upon the percentages of establishments with positive samples, annual production volume, sanitation control alternatives, geographic location, and season or month of sample collection. Results revealed low occurrence of Lm-positive samples from the random and risk-based sampling projects, with 152 (0.33%) positive samples for ALLRTE/RTEPROD_RAND and 403 (0.36%) positive samples for RTE001/RTEPROD_RISK. The percentage of positive samples significantly decreased over time, from about 0.7% in 2005 and 2006 to about 0.2% in 2017 (P < 0.05). From 2005 to 2017, 3.9% of establishments sampled under the ALLRTE/RTEPROD_RAND sampling project had at least one Lm-positive sample. Similarly, 10.0% of establishments sampled under the RTE001/RTEPROD_RISK sampling project had at least one positive sample. Samples positive for Lm were found in all geographic regions in all months. Thus, in 13 years of RTE product sampling in FSIS-regulated establishments (2005 through 2017), <0.4% of samples were positive for Lm in both risk-based and random sampling projects. The low prevalence of Lm in these products suggests that the combination of FSIS policies and industry practices may be effective for controlling Lm contamination. Information obtained from these sampling projects is relevant to the ongoing prevention of foodborne Lm illnesses from RTE meat and poultry products.

Occurrence of Salmonella in Ready-to-Eat Meat and Poultry Product Samples from U.S. Department of Agriculture-Regulated Producing Establishments. I. Results from the ALLRTE and RTE001 Random and Risk-Based Sampling Projects, from 2005 to 2012.

Ready-to-eat (RTE) meat and poultry product samples collected from RTE-producing establishments for the ALLRTE (random) and RTE001 (risk-based) sampling projects of the Food Safety and Inspection Service (FSIS) were tested for both Salmonella and Listeria monocytogenes. The FSIS analyzed Salmonella results for RTE meat and poultry product samples collected for the two sampling projects from 2005 to 2012. Data for 24,385 ALLRTE samples collected from 3,023 establishments and 66,653 RTE001 samples collected from 2,784 establishments were evaluated for the percentages of Salmonella-positive samples, product types of positive samples, and Salmonella serotypes. There also were descriptive summaries with respect to establishment hazard analysis and critical control point (HACCP) size, production volumes, L. monocytogenes control alternatives, geographic location, and season or month of sample collection. Results showed low occurrences of Salmonella-positive samples from the ALLRTE and RTE001 sampling projects, with 14 positive samples (0.06%) for ALLRTE and 33 positive samples (0.05%) for RTE001. Percentages of establishments with at least one Salmonella-positive sample averaged 0.46% for ALLRTE and 1.11% for RTE001. Three product types-sausage products, pork barbecue, and head cheese-accounted for 62% of all positive samples. There were 27 distinct serotypes from 48 Salmonella isolates, with serotypes Infantis and Typhimurium being the most common (5 isolates each). All but one of the Salmonella-positive samples were obtained from establishments with HACCP sizes of small or very small. More than half of the positive samples were obtained from establishments using L. monocytogenes control alternative 3 (sanitation only, highest-risk category). Positive Salmonella samples were found in all geographic regions at all times of the year. Information obtained from these sampling projects is relevant to the prevention of foodborne Salmonella illnesses from RTE meat and poultry products.

Occurrence of Salmonella in Ready-to-Eat Meat and Poultry Product Samples from U.S. Department of Agriculture-Regulated Producing Establishments. II. Salmonella in Ready-to-Eat Pork Barbecue Products, from 2005 to 2012.

Ready-to-eat (RTE) meat and poultry product samples from the random ALLRTE and risk-based RTE001 sampling projects of the Food Safety and Inspection Service (FSIS) were tested for both Listeria monocytogenes and Salmonella. In the course of analyzing Salmonella data for calendar years 2005 to 2012, it was observed that 8 (17.0%) of 47 positive samples were from pork barbecue. The eight Salmonella-positive samples, from seven establishments in a single state, were from 1,085 pork barbecue samples tested nationwide (0.74% positive) and from 296 samples tested from that one state (2.7% positive). The seven establishments represented 30.4% of 23 federal establishments in that state that had pork barbecue samples tested for Salmonella. A follow-up sample from intensified verification testing at one of the seven establishments also was positive for Salmonella. Upon further examination, contamination appeared to be influenced by regional differences in production methods. Notably, the style of pork barbecue that tested positive for Salmonella used a vinegar- and pepper-based sauce in which the ingredients were mixed without cooking. All the establishments with Salmonella-positive samples followed the practice of first cooking the pork and then adding the barbecue sauce ingredients (vinegar, pepper, other spices, etc.) after cooking (postlethality exposure). In addition to the sauce ingredients, other possible sources of contamination included employee hygiene and food handling practices and cross-contamination from other Salmonella-contaminated products and from commonly used equipment. Based on these findings, the FSIS issued guidelines recommending changes in production methods that would minimize or eliminate pork barbecue as a potential source of foodborne Salmonella infections.

U.S. Food safety and Inspection Service testing for Salmonella in selected raw meat and poultry products in the United States, 1998 through 2003: an establishment-level analysis.

The U.S. Food Safety and Inspection Service (FSIS) pathogen reduction-hazard analysis critical control point systems final rule, published in 1996, established Salmonella performance standards for broiler chicken, cow and bull, market hog, and steer and heifer carcasses and for ground beef, chicken, and turkey meat. In 1998, the FSIS began testing to verify that establishments are meeting performance standards. Samples are collected in sets in which the number of samples is defined but varies according to product class. A sample set fails when the number of positive Salmonella samples exceeds the maximum number of positive samples allowed under the performance standard. Salmonella sample sets collected at 1,584 establishments from 1998 through 2003 were examined to identify factors associated with failure of one or more sets. Overall, 1,282 (80.9%) of establishments never had failed sets. In establishments that did experience set failure(s), generally the failed sets were collected early in the establishment testing history, with the exception of broiler establishments where failure(s) occurred both early and late in the course of testing. Small establishments were more likely to have experienced a set failure than were large or very small establishments, and broiler establishments were more likely to have failed than were ground beef, market hog, or steer-heifer establishments. Agency response to failed Salmonella sample sets in the form of in-depth verification reviews and related establishment-initiated corrective actions have likely contributed to declines in the number of establishments that failed sets. A focus on food safety measures in small establishments and broiler processing establishments should further reduce the number of sample sets that fail to meet the Salmonella performance standard.

U.S. Food Safety and Inspection Service testing for Salmonella in selected raw meat and poultry products in the United States, 1998 through 2003: analysis of set results.

The U.S. Food Safety and Inspection Service (FSIS) tests sets of samples of selected raw meat and poultry products for Salmonella to ensure that federally inspected establishments meet performance standards defined in the pathogen reduction-hazard analysis and critical control point system (PR-HACCP) final rule. In the present report, sample set results are described and associations between set failure and set and establishment characteristics are identified for 4,607 sample sets collected from 1998 through 2003. Sample sets were obtained from seven product classes: broiler chicken carcasses (n = 1,010), cow and bull carcasses (n = 240), market hog carcasses (n = 560), steer and heifer carcasses (n = 123), ground beef (n = 2,527), ground chicken (n = 31), and ground turkey (n = 116). Of these 4,607 sample sets, 92% (4,255) were collected as part of random testing efforts (A sets), and 93% (4,166) passed. However, the percentage of positive samples relative to the maximum number of positive results allowable in a set increased over time for broilers but decreased or stayed the same for the other product classes. Three factors associated with set failure were identified: establishment size, product class, and year. Set failures were more likely early in the testing program (relative to 2003). Small and very small establishments were more likely to fail than large ones. Set failure was less likely in ground beef than in other product classes. Despite an overall decline in set failures through 2003, these results highlight the need for continued vigilance to reduce Salmonella contamination in broiler chicken and continued implementation of programs designed to assist small and very small establishments with PR-HACCP compliance issues.